Product ID:ACTIVATOR, DRY ZENTHANE PLUS
MSDS Date:08/09/2000
FSC:8010
NIIN:01-441-6114
Status Code:A
MSDS Number: CKZPK

HENTZEN COATINGS INC

6937 WEST MILL ROAD
MILWAUKEE, WI 53218
US

Emergency Phone: 800-424-9300

Info Phone: 414-353-4200

Preparer: ERNEST CARTER

Cage: 09225

HENTZEN COATINGS INC

18749 MILWAUKEE, WI 53218 US

Telephone: 414-353-4200

Cage: 09225

1,2,4-TRIMETHYLBENZENE

CAS: 95-63-6

RTECS: DC3325000

LIGHT AROMATIC SOLVENT NAPHTHA (PETROLEUM)

CAS: 64742-95-6

RTECS: WF3400000

METHYL AMYL KETONE

CAS: 110-43-0

RTECS: MJ5075000

OSHA PEL 465 MG/M3;100 PPM

ACGIH TLV: 233 MG/M3;50 PPM

POLYURETHANE ACCELERATOR

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYE CONTACT:IRRITATING. WILL INJURE
EYE TISSUE IF NOT REMOVED PROMPTLY. SKIN CONTACT: CONTAINS
CORROSIVE MATERIAL. MAY CAUSE BURNS TO THE SKIN, INHALATION:
CORROSIVE IRRITANT. CAN CAUSE IRRITATION TO THE UPPER RESPIRATORY
TRACT AND MUCOUS MEMBRANES OF THE NASAL PASSAGES AND THROAT. MAY
CAUSE HEADACHE, NAUSEA, COUGHING AND DIZZINESS. INGESTION: MAY
CAUSE MUCOSAL DAMAGE.
Explanation of Carcinogenicity:THIS PRODUCT HAS NOT BEEN TESTED AS A
WHOLE FOR CARCINOGENICITY.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; SKIN ALLERGIES AND ECZEMA; CHEMICAL SENSITIZATION.

First Aid:EYE CONTACT: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF RUNNING
WATER FOR AT LEAST 15 MINUTES WHILE LIFTING EYELIDS. SKIN CONTACT:
WASH AFFECTED AREAS WITH SOAP AND WATER. INHALATION: REMOVE FROM
EXPOSUR E. INGESTION: IF SWALLOWED, CALL A PHYSICIAN OR
POISONCONTROL CENTER IMMEDIATELY.

Flash Point Method:TCC
Flash Point:=7.8C, 46.F
Lower Limits:.9
Upper Limits:8.7
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM OR ALCOHOL FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE WORN.DURING A FIRE,
IRRITATING AND HIGHLY TOXIC GASES AND SMOKE ARE PRESENT FROM THE
DECOMPOSITION/COMBUSTION PRODUCTS. KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAMES.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT OR BURST WHEN CONTAMINATED WITH WATER (CARBON
DIOXIDE RELEASED). DO NOT APPLY TO HOT SURFACES. NEVER USE WELDING
OR CUTTING TORCH ON OR NEAR P RODUCT CONTAINER (EVEN EMPTY) BECAUSE
PRODUCT (EVEN RESIDUE) CAN IGNITE EXPLOSIVELY.

Spill Release Procedures:STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED
OR SPILLED: EVACUATE ALL NON-ESSENTIAL PERSONNEL AND REMOVE ALL
SOURCES OF IGNITION (FLAMES, HOT SURFACES, ELECTRICAL, STATIC AND
FRICTIONAL SPARKS).

Handling and Storage Precautions:MUST BE TAKEN SO THAT PERSONS HANDLING
THIS PRODUCT DO NOT BREATHE THE VAPORS OR HAVE IT CONTACT THE EYES
OR SKIN. DO NOT STORE ABOVE 120 F OR BELOW 32 F. STORE LARGE
QUNTITIES IN BUILDINGS DESIGNED T O COMPLY WITH OSHA'S 29 CFR
1910.106.

Respiratory Protection:A RESPIRATOR THAT IS RECOMMENDED OR APPROVED FOR
USE IN ORGANIC VAPOR-CONTAINING ENVIRONMENTS MAY BE NECESSARY.
Protective Gloves:CHEMICAL RESISTANT GLOVES ARE REQUIRED.
Eye Protection:USE SAFETY EYEWEAR WITH SPLASH GUARDS OR SIDE SHIELDS.
Other Protective Equipment:SAFETY SHOWERS AND EYE WASH STATIONS SHOULD
BE AVAILABLE.
Supplemental Safety and Health

HCC:F4
Vapor Pres:2.14
Vapor Density:4.80
Spec Gravity:.853
VOC Pounds/Gallon:336
VOC Grams/Liter:2.8
Evaporation Rate & Reference:.400 (N-BUTYL ACETATE=1)
Solubility in Water:REACTS SLOWLY WITH WATER
Appearance and Odor:CLEAR LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:40.1078

Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZERS; STRONG ACIDS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY CONTAIN THE
FOLLOWING: CARBON MONOXIDE, CARBON DIOXIDE AND OTHER TOXIC VAPORS
DEPENDING UPON THE TEMPERATURE REACHED.

Waste Disposal Methods:RECYCLE, FUEL BLEND OR INCINERATE. DISPOSE OF IN
ACCORDANCE WITH APPLICABLE LAWS AND REGULATIONS. IT IS THE
RESPONSIBILITY OF THE OWNER OF THE WASTE TO DISPOSE OF IT PROPERLY.

======================================================================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT PROPER SHIPPING NAME:PAINT UN NUMBER: UN1263
DOT HAZARD CLASS:3 DOT LABEL: FLAMMABLE LIQUID DOT PACKAGING GROUP:
PG 111 U.S. POSTAL SERVICE: WILL NOT HANDLE.

State Regulatory Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF
SECTION 313 OF THE EMERGENCY PLANNING AND
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND OF 40 CFR
372: